Vauxhall Grandland X EGR Valve Replacement Parts

Yes, but only on diesel and some petrol turbocharged variants — the EGR (Exhaust Gas Recirculation) valve is fitted to combustion engines where exhaust gas is recirculated to reduce emissions, and all Grandland X engines fall into this category. The Grandland X was sold in the UK from 2017 onwards with 1.2 petrol turbo, 1.6 petrol turbo, and 1.5 and 2.0 diesel engines, and all of these carry an EGR valve. Fully electric or plug-in hybrid variants that run solely on electric power would not use one, so confirm your fuel type and engine code before ordering.

The Grandland X received a significant facelift in 2019, which also brought updated powertrains and revised engine management calibrations, so the 2018 (pre-facelift) and 2021 (post-facelift) cars sit either side of an important boundary. The engine code is the key factor — if both cars share the same engine code, fitment is more likely, but the emissions calibration differences between Euro 6b and Euro 6d-temp or Euro 6d variants mean a direct swap across the 2019 facelift line should be confirmed with the breaker against your exact registration before buying.

No, trim level does not affect EGR valve fitment on the Grandland X — SE Nav, Elite Nav, and Ultimate are cosmetic and equipment packages that do not change the engine or exhaust gas recirculation system. What matters is your engine code and fuel type, which you can find on your V5C or by asking the breaker to check against your registration. Expect cosmetic differences between stripped-out breaker parts and your own car, but the valve itself should be engine-driven, not trim-driven.

No — the 1.5-litre diesel (engine code D15DT or similar) and the 2.0-litre diesel (B20DTH and variants) are different engines with different EGR assemblies, so they are not interchangeable. Always match the engine code exactly, which you can find on your V5C or by checking the engine bay plate, and quote it to the breaker when requesting a part. Mixing EGR valves between these two engines is likely to result in incorrect fitment or emissions faults.

The Grandland X shares its PSA-derived platform and some engines with the Peugeot 3008 and Citroën C5 Aircross, so there is a reasonable chance of parts commonality if the engine codes match exactly. However, whether a specific EGR valve from one of those donor vehicles will physically and electronically fit your Grandland X is something you must confirm with the breaker against your registration, as software calibration and connector differences can exist even between otherwise identical-looking parts. Do not assume platform sharing means the part will swap without verification.

Yes, it matters — the Grandland X was only ever sold new in Euro 6 specification, but within Euro 6 there are sub-standards (Euro 6b, Euro 6d-temp, Euro 6d) that were phased in during the model's life, and EGR valves can be calibrated differently to meet those stricter limits. Fitting an EGR valve from the wrong emissions sub-era could cause fault codes, failed emissions tests, or MOT issues even if the part looks identical. Always quote your registration and engine code to the breaker so they can match the correct specification.